Your Electric Trolley FAQs Answered

Please check the motor connectors on the controller box and if connector pins are in the correct position.  

Please check the battery power. Also, the controller box has a shut-down function if the battery is too low or the controller is overheating. (in addition, if you do not press any button on the remote control golf trolley within 40 seconds, the trolley will stop by itself; it is a safe function.)

Please make sure that the weight distribution of your golf bag is balanced on the caddy. To adjust the tracking, loosen the axle screw of the front wheel, and adjust the wheel position accordingly. Please check the below photos; you will understand it. For example, if the cart goes to the left, you need to adjust the wheel shift to the right a little.

You can purchase a new remote handset from your trolley dealer or manufacturer. After you receive your new remote handset, please connect the battery to the trolley. Turn the main switch to the ON position; remote control power is on too. Then press the forward button on the remote transmitter until the caddy moves (around 20 seconds, or try it again), and a new remote handset is OK.

By the way, if your remote control loses contact with the cart, you also can program it like the above steps.

Carbon Golf Trolley User Manual

WARNING: PLEASE FOLLOW ALL ASSEMBLY INSTRUCTIONS AND READ THE OPERATING INSTRUCTIONS BEFORE YOU OPERATE THE CADDY

When two or more people use the cart together, please do not put on the power at the same time on the handle control system; the interval is 5 seconds. The first cart leaves in the first 5 seconds, the second cart leaves in the second five seconds... Drives out in sequence. This is to prevent the wrong pairing between the trolley and remote control, which will cause the remote control to control the cart chaotically.

Wenn zwei oder mehr Personen den Wagen zusammen verwenden, schalten Sie bitte nicht gleichzeitig die Stromversorgung am Griffsteuerungssystem ein, das Intervall beträgt 5 Sekunden. Der erste Wagen fährt in den ersten fünf Sekunden, der zweite Wagen in den zweiten fünf Sekunden... Er fährt in der Folge raus. Dies verhindert eine falsche Kopplung zwischen Trolley und Fernbedienung, die dazu führt, dass die Fernbedienung den Wagen chaotisch steuert.

Cuando dos o más personas usen el carrito juntos, no encienda la fuente de alimentación del sistema de control del mango al mismo tiempo, con un intervalo de 5 segundos. El primer coche se fue en los primeros cinco segundos, y el segundo se fue en los últimos cinco segundos... Salga en orden. Esto es para evitar el emparejamiento incorrecto entre el carrito y el control remoto, lo que resulta en un control caótico del carrito por parte del control remoto.

1. Assembly Instructions

Fit the rear wheel by releasing the quick catch on the outside of the wheel while inserting the wheel onto the axle. There are 2 grooves on the axle. Inside groove for driving, outside groove for pushing; once your battery is empty, you can use it like a push trolley. Make sure that the right wheel is attached to the right side and the left wheel to the left. Reverse the action to remove the wheel.

motor

axle spocket

inside groove

outside groove

wheel clutch

Quick-release button

The battery cable is fitted to connect to either the trolley or to the battery charger. Place the battery in the battery tray and secure the battery using the Velcro strap. Insert the battery connector into the plug on the caddy and secure with the connector nut. Make sure the caddy's power switch on the handle is in the Off position and the speed dial is pulled back.  

Text under image: Adjusting handle height to what you want, tighten the upper pentagonal handwheel.

2, Handle Control Functions

Speed +/-

Timer: Stop automatically by pressing

Once ~ 10m

Twice ~ 20m

Three times ~ 30m

On/Off: Press for 2 seconds

Stop: Press short

Go: Press short -> automatically to the last speed setting

3. Remote Control (only for remote-controlled golf trolley)

• Emergency Brake: The red button in the middle of the directional arrows is the emergency brake
• Timer: 10, 20, 30 yards, and Stop (same as manual control timer function)
• Forward Arrow: Pushing the forward arrow will set the caddy in forward motion.
• Left Arrow: Initiates left turns. When the arrows are released, the caddy stops turning and continues straight with the original speed prior to turning.
• Right Arrow: Same as left arrow function
• Backward Arrow: Pressing the back arrow will set the caddy in backward motion
• On/Off button: On the side of the remote control for its power ON or OFF.

4. Important Notes – PLEASE READ CAREFULLY

Change the remote control batteries once the indicator LED gets weak. The remote control uses two 1.5V AAA batteries available in any supermarket, drugstore, or electronics store

It is recommended to keep a set of extra batteries ready as a replacement.

To change the batteries open up the battery compartment cover and place the batteries according to the diagram in the battery compartment  

The remote control system is designed so it does not interfere with other electric caddies.  

The maximum range of the remote control varies between 80-120 yards, depending on the battery charge, obstacles, atmospheric conditions, power lines, and the topography of the course.  

It is strongly recommended to operate the caddy at a maximum range not exceeding 40 m in order to prevent the loss of control of the unit!

Please do not let the charger connect to the power all the time; if you do not need to charge the battery, please pull out the charger.

Please do not charge the battery for more than 8 hours.

If your cart's battery is empty, please fix 2 rear wheels into the outside groove on the motor axle; you can use it like a pushcart. If you push the cart but 2 wheels are into the inside groove, it will shorten controller life as of current!!! also lead to the remote control losing contact with the cart.

PLEASE CHARGE THE BATTERY FULL BEFORE USING IT ON THE GOLF COURSE.

5, Battery Use and Care

PLEASE OBEY THESE PRECAUTIONS FOR BATTERY USE & CHARGING

1. a) Please do not charge the battery in a sealed container or in an upside-down position. It is recommended to charge the battery in a well-ventilated area.
2. b) Please do not charge the battery near a heater or where heat accumulation may occur or in direct sunshine.
3. c) In order to prolong the service life of the battery, please avoid complete discharge and charge the battery after every use. When the trolley is not in use for an extended period of time, it is recommended to charge the battery once a month.
4. d) The battery's poles' red colour stands for positive and the black for negative. In case of battery replacement, please reconnect the poles of the battery correctly. Otherwise, your caddy could suffer severe damage.
5. e) Please do not disassemble the battery or throw it into a fire. EXPLOSION!!!

NEVER TOUCH THE ELECTRIC POLES OF THE BATTERY!! SAFETY HAZARD!!

1. f) Charge the battery following the information from the charger sticker.
2. g) If you are not using the trolley, please take away the battery from the trolley. And charge the battery to full when stocking it. 

 

6, Electronic Systems

Safety Protection:

When the temperature of the controller box reaches its upper limit in case of an overload, it will automatically shut down to cool off.  

Microprocessor-Controlled Electronics System:

When you connect the battery, the electronics system will automatically run through a start-up routine. Then you can press the main OFF/ON switch on the handle. The battery charge indicator lights will show you the charge level of the battery from green (fully charged) to red (discharged).  

Important: The electronics controller box contains no user-serviceable parts. Therefore, it is sealed to reduce the risk of moisture entering and impacting the electronic system. Breaking this seal increases the risk of damaging the electronics and decreasing the reliability of your caddy. DO NOT attempt to open the controller case. Doing so will void the warranty!  

Battery Operation and Care:

Follow battery charge and maintenance instructions. The battery comes with leads and a connector and a 30 or 40 Ah fuse.

WARNING

1. It is strongly recommended to operate the cart at a maximum range not exceeding 40 m in order to prevent the loss of control of the unit. Please charge the battery full before you use the cart.
2. Please do not let the charger connect to the power all the time; if you do not need to charge the battery, please pull out the charger. Please do not charge the battery for more than 8 hours.
3. If your cart's battery is empty, please fix 2 rear wheels into the outside groove on the motor axle; you can use it like a pushcart. If you push the cart but 2 wheels are into the inside groove, it will shorten controller life as of now!!! also lead to the remote control and lose the contact with the cart.
4. If you do not use the trolley, please take away the battery from the trolley; if the battery is connected with the trolley always, the standby also consumes power of the battery; it will let the battery power less and less until the battery empties to death.
5. Charging the battery to full before stocking it. And if the cart is stocked exceeding 60 days, you should take out the battery and charge it fully, then stock it again, or the battery will be dead as of the empty power.
6. If you do not use the remote control, please be sure to remove the small battery inside the remote control, because the small battery will leak or rot, which is stored in the remote control for a long time, resulting in damage to the remote control.

 

1. Es wird dringend empfohlen, den Wagen mit einer maximalen Reichweite von nicht mehr als 40 m zu betreiben, um einen Kontrollverlust über das Gerät zu vermeiden. Bitte laden Sie den Akku vollständig auf, bevor Sie den Wagen verwenden.
2. Bitte lassen Sie das Ladegerät nicht die ganze Zeit an die Stromversorgung anschließen. Wenn Sie den Akku nicht aufladen müssen, ziehen Sie bitte das Ladegerät heraus. Bitte laden Sie den Akku nicht länger als 8 Stunden auf.
3. Wenn der Akku Ihres Wagens leer ist, befestigen Sie bitte 2 Hinterräder in der äußeren Nut an der Motorachse, Sie können ihn wie einen Schiebewagen verwenden. Wenn Sie den Wagen schieben, aber 2 Räder in der Innenrille sind, verkürzt dies die Lebensdauer des Controllers!!! auch dazu führen, dass die Fernbedienung den Kontakt zum Wagen verliert.
4. Wenn Sie den Trolley nicht verwenden, nehmen Sie bitte die Batterie aus dem Trolley.
5. Laden Sie den Akku vollständig auf, bevor Sie ihn lagern. Und wenn der Wagen länger als 60 Tage vorrätig ist, sollten Sie den Akku herausnehmen, ihn voll aufladen und dann wieder auffüllen, oder der Akku wird bei leerem Strom tot sein.
6. Wenn Sie die Fernbedienung nicht verwenden, achten Sie bitte darauf, die kleine Batterie in der Fernbedienung zu entfernen, da die kleine Batterie ausläuft oder verrottet, die in der Fernbedienung für eine lange Zeit gespeichert ist und zu Schäden an der Fernbedienung führt.

 

1. Se recomienda encarecidamente operar el carro a un alcance máximo que no exceda los 40 m para evitar la pérdida de control de la unidad. Cargue la batería por completo antes de usar el carrito.
2. no permita que el cargador conecte la alimentación todo el tiempo, si no necesita cargar la batería, extraiga el cargador. No cargue la batería durante más de 8 horas.
3. Si la batería de su carrito está vacía, fije 2 ruedas traseras en la ranura exterior del eje del motor, puede usarlo como un carrito de empuje. Si empuja el carro pero hay 2 ruedas en la ranura interior, ¡acortará la vida útil del controlador a partir de la actualidad! También provocará que el mando a distancia pierda el contacto con el carro.
4. si no está utilizando el carro, retire la batería del carro, si la batería se conecta con el carro siempre, el modo de espera también consume energía de la batería, dejará que la batería se cargue cada vez menos, hasta que la batería se agote hasta la muerte .
5. cargando la batería por completo antes de almacenarla. Y si el carro está almacenado por más de 60 días, debe sacar la batería y cargarla por completo y luego almacenarla nuevamente, o la batería se agotará a partir de la energía vacía.
6. si no utiliza el control remoto, asegúrese de sacar la pequeña batería en el control remoto, porque la pequeña batería se filtrará o se pudrirá, y se almacenará en el control remoto durante mucho tiempo, lo que causará daños en el control remoto.